Product ID:R6X19 SECONDARY BUTANOL
MSDS Date:03/08/1996
FSC:8010
NIIN:00F053351
MSDS Number: CDRDR

Emergency Phone: 216-566-2917/216-566-2902

Info Phone: 216-566-2902/216-566-2917

Cage: 54636

Telephone: 800-251-2486/216-566-2242

Cage: 54636

SEC-BUTANOL ALCOHOL

CAS: 78-92-2

RTECS: EO1750000

Fraction By Weight: 100%

OSHA PEL 150 PPM

ACGIH TLV: 303 MG/CUM

Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE IRRITATION OF EYES, SKIN &
RESPIRATORY SYSTEM. NERVOUS SYSTEM DEPRESSION. MAY RESULT IN DEATH.
PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE ADVERSE EFFECTS TO THE
BLOOD-FORMING & REPRODUCTIV E SYSTEMS & MAY CAUSE PERMANENT BRAIN
&NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, UNCONSCIOUSNESS, HEADACHE,
DIZZINESS, NAUSEA, LOSS OF COORDINATION, REDNESS, ITCHING, BURNING
SENSATION.
Medical Cond Aggravated by Exposure:NONE

First Aid:INHALATION: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM & QUIET. SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH
W/LARGE AMOUNTS OF WATER FOR 15 MINS. INGESTION: NEVER GIVE
ANYTHING BY MOUTH IF UNCONSCIOUS. DON'T INDUCE VOMITING. GIVE
SEVERAL GLASSES OF WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.

Flash Point:73F
Lower Limits:0.8
Upper Limits:12.7
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT W/SCBA. WATER
SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERRED. WATER MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT & OTHER IGNITION SOURCES. CLOSED CONTAINERS MAY EXPLODE
WHEN EXPOSED TO EXTREME HEAT.

Spill Release Procedures:REMOVE IGNITION SOURCES. VENTILATE & REMOVE
W/INERT ABSORBENT.

Handling and Storage Precautions:KEEP FROM HEAT & OTHER IGNITION
SOURCES. USE APPROVED BONDING & GROUNDING PROCEDURES. KEEP
CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:TRANSFER ONLY TO APPROVED CONTAINERS W/COMPLETE &
APPROPRIATE LABELING. DON'T TAKE INTERNALLY. KEEP OUT OF REACH OF
CHILDREN. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING &
INHALING THE CONTENTS C AN BE HARMFUL/FATAL.

Respiratory Protection:WEAR A PROPERLY FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA.
Ventilation:LOCAL/GENERAL EXHAUST VENTILATION.
Protective Gloves:RECOMMENDED
Eye Protection:SAFETY GLASSES W/UNPERFORATED SIDESHIELD
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
AVOID BREATHING VAPORS & SPRAY MIST, CONTACT W/SKIN, EYES & CLOTHING.

Boiling Pt:B.P. Text:178-415F
Vapor Density:>1
Spec Gravity:0.75
VOC Grams/Liter:6.69
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, ELECTRICAL
EQUIPMENT, HOT SURFACES & OTHER IGNITION SOURCES
Hazardous Decomposition Products:BY FIRE: CO2, CO

Waste Disposal Methods:WASTE MUST BE TESTED FOR IGNITABILITY TO
DETERMINE THE APPLICABLE EPA HAZARDOUS WASTE NUMBERS. INCINERATE IN
APPROVED FACILITY. DON'T INCINERATE CLOSED CONTAINERS. DISPOSE OF
IAW/LOCAL, STATE & FEDERA L REGULATIONS. FLAMMABLE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.